ISU® Speciality Containers

AAR Mobility Systems

ISU® Shipping and Storage Containers
ISU® =  Internal Airlift/Helicopter Slingable Container Unit

Dog Kennel Container

As the sole manufacturer of the ISU® Container, AAR Mobility Systems has designed over 40 different configurations that can be easily customized to meet your mission requirements.

 

 

 

 

 

 

 

ISU® 90 LAUNDRY UNIT

ISU Laundry Unit
  • Part Number: 56102-497 Green
  • NSN: 8145-01-472-7758
  • Dimensions: 108”W X 88”L X 91.35”H
  • Weight:  3,200 lbs.
  • Payload Capacity:  6,800 lbs.
  • Maximum Gross Weight:  10,000 lbs.
  • Other colors available
  • 208 VAC/3-Phase Electrical Power Unit
  • Power cable
  • Four unitized washers/dryers installed – 2 on each side
  • Dryer vents and hose with screens to filter water sediment and prevent rodent intrusion
  • Foot valve for pond or stream water pickup
  • Self-priming pump for use with a water bladder or used to increase water pressure in system
  • Fluorescent lighting – one on each side
  • Awning cover for each side when doors are open

 

ISU® 90KCI 3-DOG KENNEL

Dog Kennel Container
  • Part Number: 56133-160 Tan
  • NSN : 8145-01-490-3765
  • Dimensions: 108”W X 88”L X 91.35”H
  • Weight:  2,300 lbs.
  • Payload Capacity:  9,240 lbs.
  • Maximum Gross Weight:  11,540 lbs.
  • Other colors available
  • The safest and most efficient way to transport and billet three security dogs in one pallet position 
  • Dog doors installed on each kennel door
  • Kennel access door with open bar gate for each animal
  • Dog runs include fencing free of pinch points and sharp corners, fencing roof swings back to allow easy access, shields between runs, and sloped decking allowing for easy cleaning
  • Storage quadrant for supplies along with eight additional shelves
  • Two hazmat doors for equipment loading and inspection
  • Dog doors are vertical 2-way swinging with locking capability installed on each kennel door
  • Environmental control unit installed to keep dogs comfortable

 

ISU® 90EO WEAPONS ROOM

Containerized Weapons Room
  • Part Number:  56121-XXX Green
  • Dimensions: 88”W X 108”L X 91.35”H
  • Weight:  1,510 lbs.
  • Payload Capacity:  5,000 lbs.
  • Maximum Gross Weight:  6,510 lbs.
  • Other colors available
  • One door on one 88” side with dual lock rods
  • Designed without center wall to accommodate various weapons room configurations
  • All weapons racks are factory installed
  • Each weapons rack can be padlocked with easy access to each weapon when stored
  • Weapons rooms are configurable to meet mission requirements based on quantity and type of weapon

 

96ATV 4-DOOR

Four Door ATV Container
  • Part Number: 56179-000 Green
  • NSN : 8145-01-465-4180
  • Dimensions: 108”W X 88”L X 96”H
  • Weight:  2,180 lbs.
  • Payload Capacity:  7,820 lbs.
  • Maximum Gross Weight:  10,000 lbs.
  • Other colors available
  • Four doors – two on each 108” side
  • Room for two small ATV’s, two small cargo-hauling trailers, fuel and equipment
  • Optimized for maximum cargo flexibility
  • Includes 72” support shelf and ATV ramp
  • Shelf has 6-point shelf support

 

65I ATV 4-DOOR

Four Door Military ATV Container
  • Part Number: 56194-000 Tan
  • NSN : 8145-01-511-3250
  • Dimensions: 108”W X 88”L X 65”H
  • Weight:  1,450 lbs.
  • Payload Capacity:  8,550 lbs.
  • Maximum Gross Weight:  10,000 lbs.
  • Other colors available
  • Four doors - two on each 108” side
  • Room for two small ATV’s, one small cargo-hauling trailer, fuel and equipment
  • An additional 1,500 lbs. of cargo can be stored on top
  • 6” aisle meets c-130 safety of flight requirements

 

ISU® 96RC Refrigerated Container

Refrigeration Container
  • Part Number: 50148-006 Tan
  • NSN : 8145-01-422-9084
  • Dimensions: 88”W X 108”L X 97”H
  • Weight:  3,250 lbs.
  • Payload Capacity:  6,750 lbs.
  • Maximum Gross Weight:  10,000 lbs.
  • Other colors available
  • One door on one 88” side – door is 49.5” wide with 46.88” opening
  • C-130 aisle access on 88” end
  • Air transport certified, self-contained refrigerated container for storage of temperature sensitive and perishable items
  • Integral diesel refrigeration unit or 208/230-volt, 3-phase electric refrigerated system allows container to maintain temperature even while in transport
  • Refrigeration Container System
    Constructed of FRP skinned composite panels mounted on a formed aluminum pallet base
  • Compatible with 463L cargo system
  • Pallet base includes forklift pockets and removable 463L compatible cargo rails on all four sides
  • Designed to meet FDA requirements
  • Montreal Protocol approved refrigerant (R-404A)
  • Interior light works with shore power
  • Start/stop operation to maintain temperature and conserve fuel
  • Helo-sling lift and tie-down rings attached to four top corners of container
  • Intermodal by air, helo, land, sea and rail

 

ADR 300 - Advanced Design Refrigerator

Compartmental Refrigeration Container
  • Part Number: 56149-000 Green
  • NSN: 4110-01-465-4158
  • Dimensions: 75”W X 108”L X 96”H
  • Weight:  3,285 lbs.
  • Payload Capacity:  6,715 lbs.
  • Maximum Gross Weight:  10,000 lbs.
  • Other colors available
  • One door on 88” side
  • C-130 aisle access on 88” end
  • Refrigeration Unit mounted in one 108” side wall panel and includes power entry and control components
  • Shelving for Container
    Interior racks with five removable/adjustable shelves on each side wall
  • Operates on 230-Volt/3 Phase/60 Hz (can be manufactured to 380-Volt/3 Wye/50 Hz for Europe)
  • Montreal Protocol approved refrigerant (R-404A) 
  • Constructed of FRP skinned composite panels mounted on a formed aluminum pallet base
  • Lever activated container door escape lock
  • Tread pattern floor with drain to reduce slipping and improve traction
  • Interior lit by single light fixture above door controlled by switch
  • Compatible with 463L cargo system
  • Pallet base includes forklift pockets and removable 463L compatible cargo rails on all four sides
  • Helo-sling lift and tie-down rings attached to four top corners of container
  • Intermodal by air, helo, land, sea and rail

 

ISU® 90I HSC High Security Container

High Security Container
  • Part Number: 56190-000 Green
  • NSN: 8145-01-500-3147
  • Dimensions: 88”W X 108”L X 93.67”H
  • Weight:  6,035 lbs.
  • Payload Capacity:  5,965 lbs.
  • Maximum Gross Weight:  12,000 lbs.
  • Other colors available
  • One door on 88” side
  • NIJ 0108.00 Level IIIA Ballistic protection
  • Armor plate exterior, forced entry resistant
  • Single outside armor plate door with high security hasp and padlock
  • Steel interior dutch door with pass through for issue of weapons or secured items
  • Nominal 36” X 84” main and dutch doors
  • Two 30” fluorescent light fixtures, three bulbs each
  • Power distribution system
  • 240 VAC single phase power unit
  • Interior mounted load center with 4 branch circuits
  • Surge protection on service entrance
  • Interior duplex outlets
  • Dehumidification system to control humidity
  • Security alarm system
  • Interior tie-down rings
  • 4-way forkliftable with standard 10,000 lb. fork trucks with 72” tines
  • Air transportable within fixed wing aircraft
  • Sea transportable with MIL-VAN, flatracks or gondola

 

EISU - Expandable ISU®

ISU Expandable
  • Part Number: 56240-000 Tan
  • Dimensions: 88”W X 108”L X 91.47”H Stowed ; 245.2”W X 108”L X 91.47”H Deployed
  • Weight:  2,500 lbs.
  • Payload Capacity:  7,500 lbs.
  • Maximum Gross Weight:  10,000 lbs.
  • Other colors available
  • 3-in-1 expandable version of the ISU 90 Container
  • Wing walls of stowed container fold down to serve as floors in deployed mode
  • Side rooms enclosed within durable fabric walls and ceiling, supported by simple strut
  • Easily deployed by 2 personnel in less than 15 minutes 
  • Designed for internal air transport and helicopter sling lift 
  • Expandable ISU Container
    Integral 463L air cargo pallet base - loads directly into aircraft cargo restraint system, as do all of AAR's ISU®  containers
  • Four-way forkliftable
  • Two electrical shore-power hook up and interior 4-gang 120V receptacles
  • Non-insulated fabric walls
  • Two scissor-jacks on each side for wing-wall support

 

EISU Shower Unit

Containerized Shower Unit
  • Part Number: 56240-731 Tan
  • Dimensions: 88”W X 108”L X 91.47”H Stowed ; 245.2”W X 108”L X 91.47”H Deployed
  • Weight:  3,200 lbs.
  • Payload Capacity:  6,800 lbs.
  • Maximum Gross Weight:  10,000 lbs. 
  • Other colors available
  • Six Showers – three on each side
  • Four sinks – two on each side
  • Hot water heater and connecting hose
  • Fresh water pump and connecting hoses
  • Gray water waste pump and connecting hoses
  • Fresh water bladder
  • Gray water bladder
  • 110-120 VAC/60 Hz/30 Amp/Single Phase Electrical with 2.7kW GFI Circuit Breakers
  • Floor leveling jacks
  • Ground rod kit
  • 30-foot input power cable

 

EISU Latrine Unit

Expandable Shelter System
  • Part Number: 56240-732 Tan
  • Dimensions: 88”W X 108”L X 91.47”H Stowed ; 245.2”W X 108”L X 91.47”H Deployed
  • Weight:  3,015 lbs.
  • Payload Capacity:  6,985 lbs.
  • Maximum Gross Weight:  10,000 lbs. 
  • Other colors available
  • Six toilets – three on each side
  • Two sinks – one on each side
  • Hot water heater and connecting hose
  • Fresh water pump and connecting hoses
  • Black water waste pump and connecting hoses
  • Fresh water bladder
  • Black water bladder
  • 110-120 VAC/60 Hz/30 Amp/Single Phase Electrical with 2.7kW GFI Circuit Breakers
  • Floor leveling jacks
  • Ground rod kit
  • 30-foot input power cable

 

EISU Combo Unit

Expandable Shelter System
  • Part Number: 61204-0002 Tan
  • Dimensions: 88”W X 108”L X 91.47”H Stowed ; 245.2”W X 108”L X 91.47”H Deployed
  • Weight:  3,155 lbs.
  • Payload Capacity:  6,845 lbs.
  • Maximum Gross Weight:  10,000 lbs. 
  • Other colors available
  • Three showers – all on one side
  • Three toilets – all on other side
  • Three sinks – two on shower side, one on latrine side
  • Hot water heater and connecting hose
  • Fresh water pump and connecting hoses
  • Black water waste pump and connecting hoses
  • Fresh water bladder
  • Black water bladder
  • 110-120 VAC/60 Hz/30 Amp/Single Phase Electrical with 2.7kW GFI Circuit Breakers
  • Floor leveling jacks
  • Ground rod kit
  • 30-foot input power cable

 

EISU Workshop

Containerized Work Space
  • Part Number: 56240-733 Tan
  • Dimensions: 88”W X 108”L X 91.47”H Stowed ; 245.2”W X 108”L X 91.47”H Deployed
  • Weight:  4,600 lbs.
  • Payload Capacity:  5,300 lbs.
  • Maximum Gross Weight:  10,000 lbs.  
  • Other colors available
  • 110-120 VAC/60 Hz/60 Amp Single Phase 120/280 GFI Circuit Breakers for externally powered devices
  • Two 10-Drawer full height storage cabinets
  • EISU Workshop
    Two 4-drawer bench height storage cabinets
  • Under bench drawer
  • Chair
  • 15-gallon/5-CMF @ 100-PSI air compressor
  • Internal 100-PSI compressed ¼” air quick disconnect fittings – mounted
  • External 100-PSI compressed ¼” air quick disconnect fittings – mounted
  • Chemical storage cabinet
  • Two 12” fans (220/1500 CFM)
  • One Wood workbench top
  • One 5.5kW generator – diesel/JP8
  • One Vise
  • Four External 20-Amp receptacles (5-20 R)
  • Four Fold-down floor leveling jacks
  • Workshop Containers
    Two wing lights
  • Two rough duty work lights
  • One ground rod kit
  • 30-foot 60-Amp shore power cable
  • 10-foot 60-Amp slave cable
page up
×